ZUKIWORLD Online | Suzuki 4x4 Editorial and Forum

ZUKIWORLD Discussion Forum => Suzuki 4x4 Forum => Topic started by: ExitLeft on April 19, 2007, 03:51:30 PM

Title: Trans bearing or throwout bearing?
Post by: ExitLeft on April 19, 2007, 03:51:30 PM
Just picked up a '94 Sidekick JX from a relative.  He gave it to me for nothing because he was too lazy to fix it or sell it.  He told me all it needed was a clutch job.  It has 145k miles on the origional clutch.  The symptom is that it whines like hell when the clutch is out, but is quiet when you push the clutch in.  Everything's origional on this car; engine, trans, t-case, clutch.  I haven't driven it around yet so I don't know if it makes any noise in any particular gear, but he says that the whining goes away once the 'kick warms up.  Sound like a bearing in the trans or a throw-out bearing?  I've searched this and a few other suzuki forums and found both explains the sound.  Any ideas?
Thanks,
WES
Title: Re: Trans bearing or throwout bearing?
Post by: ROSS on April 19, 2007, 04:00:46 PM
if you push the pedal to the floor and it stops whining its the trans bearing
Title: Re: Trans bearing or throwout bearing?
Post by: ExitLeft on April 19, 2007, 04:08:52 PM
That's what I thought, too.  Is it time for a rebuild/replacement?  What about draining it and adding fresh fluid (it's probably never been changed!)?  Maybe adding some Lucas Oil to the new fluid?  Any other ideas? 

Thanks again,
WES
Title: Re: Trans bearing or throwout bearing?
Post by: ROSS on April 19, 2007, 04:13:26 PM
oils cheap . i'd try it. when i got mine i drained the oil. it had alot of water in it. 
it almost looked like mud.  flushed it out good and now its fine
Title: Re: Trans bearing or throwout bearing?
Post by: BigPig on April 20, 2007, 11:55:19 AM
Mine does the same thing and it whines when driving in 5th gear.  Neither are too bad yet and I don't get many miles on it so it'll wait till I go through the engine.
Title: Re: Trans bearing or throwout bearing?
Post by: PHX96TRACK on April 22, 2007, 12:01:21 AM
Mine does this when cold. I warm it up with the clutch pedal to the floor and it makes no noise and after warm it's fine. Hoping it will not be a problem for a while
Title: Re: Trans bearing or throwout bearing?
Post by: ExitLeft on April 22, 2007, 03:34:16 PM
Mine does this when cold. I warm it up with the clutch pedal to the floor and it makes no noise and after warm it's fine. Hoping it will not be a problem for a while

Same thing here....why does it stop when it warms up??  Wouldn't a bad bearing still be bad regardless of temp?

WES
Title: Re: Trans bearing or throwout bearing?
Post by: PHX96TRACK on April 22, 2007, 10:49:12 PM
My guess is when what little lube there is left gets warm, it lubricates better and the noise goes away.