ZUKIWORLD Online | Suzuki 4x4 Editorial and Forum

ZUKIWORLD Discussion Forum => Suzuki 4x4 Forum => Topic started by: ghd23 on September 06, 2007, 04:41:44 PM

Title: No Start.
Post by: ghd23 on September 06, 2007, 04:41:44 PM

Hi All.

  To start with, I'm usually pretty good when it comes to figuring out any problems with my Trackers. Not this time!
  I need help. Its my wife's DD, 1991 Tracker 2wd, 5 speed. It has always been hard to start in the rain, but once started it always ran like a champ.  Well 2 weeks ago after a good rain it started, I ran it for about 6 blocks, shut it off and it never started again.
  After checking all the usual suspects, I changed the fuel filter and it started right up, it ran better than ever. Drove it for 3 days, put about 100 miles on it. then it just shut off at a stop light. Hasn't started since. 
I'm thinking ECM.  Any and all thoughts are eagerly welcome.

  Thanks Ahead, George. 

Title: Re: No Start.
Post by: mrfuelish on September 06, 2007, 04:50:20 PM

Go pour a little gas down the t.b.i. and see if it runs for a sec or two.

Title: Re: No Start.
Post by: daddyizzle on September 07, 2007, 07:48:17 PM

I'm thinking ignition switch because it happens when it's humid out. It would be intermittent but would only happen in moist conditions at first and then eventually fail. I live in a humid area so I have had this problem on two or three older vehicles. You might just try swapping a good used one in. I don't know if the old sammy ones work but I have one. Changing the fuel filter is good but the fact that it started right up might have only been a coincidence.

-Adam