ZUKIWORLD Online | Suzuki 4x4 Editorial and Forum

ZUKIWORLD Discussion Forum => Technical Discussion - Beginner / Repair => Topic started by: badkat on June 10, 2010, 01:29:27 PM

Title: trans oil '93 geo
Post by: badkat on June 10, 2010, 01:29:27 PM

just recently put clutch in i went to put oil that we caught back in   wouldn't hold but half of it started running out
is the plug on side of trans the only place where you fill it   or recon somebody just over filled it
                                                 thanks

Title: Re: trans oil '93 geo
Post by: badkat on June 11, 2010, 11:15:05 AM

anybody know

Title: Re: trans oil '93 geo
Post by: c10long on June 14, 2010, 01:26:49 PM

80-90w gear oil.  non-synthetic GL-4.  is what the factory calls for.  GL-4 has been replaced with gl-5.  So, GL-5.  Synthetic oil has smaller particals and some say it can seep out through your seals.    personal preference.

Title: Re: trans oil '93 geo
Post by: badkat on June 14, 2010, 09:35:06 PM

also iwent wheeling  and the clutch  started not disingaugeing al the way i tighting the cable  till it ran   out still not right
new clutch any susgesting?

Title: Re: trans oil '93 geo
Post by: c10long on June 15, 2010, 06:20:52 AM

check the clutch arm.  the part that connects to the transmission with the cable on the bottom.  make sure that isn't stripped or it slipped.   

Title: Re: trans oil '93 geo
Post by: badkat on June 15, 2010, 09:55:52 AM

thanks for your help man!!!!   i found the outer part cable   was   broke making it not pull the arm far anough

Title: Re: trans oil '93 geo
Post by: Drone637 on June 18, 2010, 09:41:20 AM

As for the oil coming out of the side, that means it's full.  You only fill it up to the fill plug, same with the transfer case.  :)