ZUKIWORLD Online | Suzuki 4x4 Editorial and Forum
ZUKIWORLD Discussion Forum => Technical Discussion - Beginner / Repair => Topic started by: rockybaroofy on February 18, 2012, 02:39:46 PM
-
does anyone know of a heater motor that is much more cfm , that will go into the stock or even slightly modified heater box ? thinking about something ?some vehicle with large interior space like a van would have a bigger cfm heater motor . has anyone tried anything like this ?
-
Clean the heater core out, on my Sidekick and my cousins Sammi with a clean core there is far more heat than needed, enough to sweat ya out, even when the temp is down in the low teens.
A beanie is needed in the winter to prevent an ice cream headache no matter what with a soft top,,,LOL
-
talon , the heater core is brand new and the inside of the heater box i cleaned to eating cleanliness myself there just isnt' enough heat/ air com,ing out of the motor . this isnt' just this one case , i have three trackicks and all three dont; put out beans for cfm ! I took a bet with my dad that a leaf blower would make it heat better and he was right ! so it has to be the blower motor isn't up to snuff or i need a bigger motor to replace the stocker
-
The resistor pack may be bad and not allowing full speed. Try wiring the blower motor directly from a seperate 12vdc fused source to check it out. There is also 2 heater ducts that blows under the seats, these can be altered to blow the heat towards the feet instead of under the seat.
I have a lot of air flow when on high with my Sidekick and it is comfy with OAT down around zero and 55mph
-
Flex-a-lite makes a "replacement" heater, 140cfm and 12000btu's. Might be an option to use as a replacement or in addition to the stock system if it doesnt provide enough airflow for your desires.