ZUKIWORLD Online | Suzuki 4x4 Editorial and Forum

ZUKIWORLD Discussion Forum => Suzuki 4x4 Forum => Topic started by: chance_S on March 09, 2005, 08:18:52 AM

Title: carb problems/ anyone selling a weber
Post by: chance_S on March 09, 2005, 08:18:52 AM
i have a 87 samuria with a stock carb and it wont idle under 1500 rpm so i got the idle screw cranked out so i can drive it. if u have any idea how to fix this other then a weber (seeing how they are on strike) please help. i have checked for vacumn leaks there are none.
???
if you are sellin a weber for a samuria for under 400 dollars please let me know i will gladly buy it from you if its pretty new
Title: Re: carb problems/ anyone selling a weber
Post by: ebewley on March 09, 2005, 08:42:20 AM
Quote
i have a 87 samuria with a stock carb and it wont idle under 1500 rpm so i got the idle screw cranked out so i can drive it. if u have any idea how to fix this other then a weber (seeing how they are on strike) please help.
???
if you are sellin a weber for a samuria for under 450 dollars please let me know i will gladly buy it from you if its pretty new


Are you aware that there are three adjustments that can effect your idle speed? There is the cold / fast idle adjustment that is the more obvious adjustment at the back of the carb close to the cable pull linkage. The warm idle adjustment is also at the back of the carb but is tucked underneath a fair share of hoses and is located at the baseplate of the carb. The third place that could be effecting your idle is the idle up circuitry adjustment. The idle up / accessory on idle adjustment is a large(ish) bolt located at the back of the carb that a vacuum plunger pushes on to idle up the vehicle whenever an accessory is turned on (lights, heater) or you are above a certain altitude.

Try checking and/or adjusting (if needed) these first.

But wait! Do you have a vacuum leak? Did this problem just start happening? Check for crack/broken/misfitting hoses and possible leaks at the baseplate of the carb..

Good Luck, Eric

PS. Wasn't there a thread on here that had some carb pictures? I seem to recall there was.... Anyone remember?
Title: Re: carb problems/ anyone selling a weber
Post by: ROSS on March 09, 2005, 12:59:28 PM
THE CARB PICS WERE  EFI. I HAVE A WEBER TWO YEARS OLD . WORKS GOOD.  $200.00 WHERE YOU LIVE? WENT TO EFI. IT EVEN RUNS UPSIDE DOWN.

                                          ROSS
Title: Re: carb problems/ anyone selling a weber
Post by: HUMZUKI on March 10, 2005, 12:48:55 AM
Dude,,,,,There not $450 new. ::)
Title: Re: carb problems/ anyone selling a weber
Post by: Bobzooki on March 10, 2005, 03:08:16 AM
Quote
THE CARB PICS WERE  EFI.


Now that is a confusing statement!